Kimberling City (417) 739-5912 | Shell Knob (417) 858-6366

Services

At Table Rock Boats, it is our service that makes the difference! We always say that the sales team sells the first boat and the service team sells the next 5 and we truly believe it. When it’s time for maintenance or repairs, your first stop should be Table Rock Boats. Our service department goes the extra mile to ensure that our work lives up to our reputation. Our certified technicians are among the most highly trained on Table Rock Lake.

Some of the Services we offer are:

· Engine Oil & Filter Changes
· Engine Tune-Up
· Complete Sterndrive Service
· Change Transmission Oil
· Bilge Pump Safety Equipment Inpsections
· Steering Systems Maintenance & Repair
· Ballast System Maintenance & Repairs
· Engine/Prop Shaft Alignment
· Comprehensive Electrical System Check
· Mechanical and Electrical Repairs and Inspections
· Cleaning, Detailing, Buffing and Wax Available Upon Request

Winterization

Our winterization efforts are among the most comprehensive in the area to prepare your boat for storage in the off season. Our certified technicians check your boat and engine for open service bulletins, run the engine(s) to temperature, change oil & oil filter, drain raw water from engine cooling system and flush with non-toxic antifreeze, clean raw water strainer, stabilize fuel and test your batteries. Of course, not all boats are created equal so we customize our process to your boat to make sure all systems needs are met.

De-Winterization

De-Winterization efforts prepare your boat for launch. Our experts hook up batteries, confirm your engine starts, ensure your motor purrs and check for any leaks. We perform a courtesy inspection of your boat lights and horn and make sure your boat is ready to hit the water. For boats with ballast systems, we run them through a complete fill and empty cycle to ensure that everything is working properly and that fill and empty times are accurate. We typically change raw water impellers and ballast pump impellers in the Spring as well.

10-Hour Service Check

Boat maintenance differs from boat to boat and engine to engine. Lucky for you, we have years of experience under our belt and understand the requirements for fine-tuning your vessel. We inspect fuel hose connections, fittings, engine alignment, electrical harnesses and the condition of your boat’s drive lube and transmission fluid. Our technicians run a diagnostic boat check and deliver an oil and filter change at every service check level.

20 Hour Service Check (Outboards)

The first service is the most important service! At the first 20-hour service and inspection, we follow the manufacturer guidelines on all checks and inspections to ensure that your engine life is maximized. We change the engine oil and filter, change the gear lube in the lower unit and go through a whole host of checks and inspection points.

20 Hour Service Check (Inboards)

You’ve used your boat hard for the first 20 hours and hopefully you’ve nailed that new surf/wakeboard trick, but now it’s time to take care of your baby, err, your boat! During this check, we are looking things over in your engine compartment from head to toe to ensure that things are how they are supposed to be. We change the engine oil and filter, change the transmission fluid and check the filter for premature wear, change the water pump impeller, check the fuel line and connections, clean the raw water strainer, check for any error codes and any open service bulletins or recall notices, check all belts and hoses for premature wear, verify accuracy of gauges and just generally give it the once over. This service is critical because the oils used in a new engine are for break-in periods only so it is important to change to full synthetic to ensure your warranty stays intact.

50 Hour Service Check (Sterndrive)

This check is especially important for sterndrive boats because not only are we changing the engine oil but we are also changing the sterndrive gear lube. We are looking for signs of excess wear and we are changing you over from break-in oil to full synthetic oil in both your engine and outdrive. This ensures the longest life for your new boat. During this service, we will remove the sterndrive from the boat and reinstall while aligning the engine to the driveline. In addition, we will change the water pump impeller, change the fuel filter, check the fuel line and connections, check the u-joint bellows, check the power trim fluid and pump connections, check for any error codes and any open service bulletins or recall notices, check all belts and hoses for premature wear, verify accuracy of gauges and just generally give your boat a once over.

100-Hour Service Check

100-hour service checks include all the services of the 20- and 50-hour service check. In addition, we change your at water or outboard engine water pump impeller, along with any maufacturer recommended services or inspections.

Annual Service

Boat maintenance differs from boat to boat and engine to engine. Lucky for you, we have years of experience under our belt and understand the requirements for fine-tuning your vessel. Below are many of the most common items that should be done annually to maximize your time on the water and minimize your time in the shop.

Annual Inboard Maintenance Annual Sterndrive Maintenance
• Change Engine Oil & Filter
• Replace Fuel Filter
• Check Engine Mounts
• Check Propeller Shaft Alignment
• Change Water Pump Impeller- Pumps water to engine for cooling
• Change Ballast Pump Impeller(s)
• Inspect Air Filter
• Check Engine Computer for Error Codes
• Check for Campaign Recalls
• Check Belts & Hoses for Wear
• Inspect the Steering System
• Inspect Shift & Throttle System
• Check Fuel Pump & Fuel Lines for leaks
• Check Exhaust Hoses for leaks/tighten
• Check Coolant Level/Check for Leaks
• Check Fire Suppression Equipment
• Test the Batteries and check connections

Every 3 Years or 300 hours:
• Change Transmission Fluid
• Engine Tune-Up including changing spark plugs and spark plug wires
• Replace Batteries
Engine
• Change Engine Oil & Filter
• Replace Fuel Filter
• Change Water Pump Impeller‐ Pumps water to engine for cooling
• Check Engine Computer for Error Codes
• Check for Campaign Recalls
• Check Serpentine Belt
• Check Circulating Water Pump Pulley‐Tighten Bolts
• Check PCV Valve
• Check Fuel Pump & Fuel Lines for leaks
• Check Flame Arrester
• Check Exhaust Hoses for leaks/tighten
• Check Coolant Level/Check for Leaks
• Check Spark Plugs
• Check Distributor Cap & Rotor

Sterndrive
• Change Gear Lube
• Inspect Anodes‐ Replace if Eroded
• Check Propeller and propshaft for damage‐ Lubricate

Every 2nd Year
• Replace U‐Joint Bellows‐ Seal between outdrive and engine, keeps water from coming into boat

Every 3rd Year or every 200 hours:
• Tune‐Up/Replace Spark Plugs
• Replace Batteries

For your convenience, we offer pick up and delivery services. Table Rock Boats transports your vessel from the dock to our service location. After maintenance and repair work is complete, we’ll return your boat safely back home again. Let us take the worry out of this boating season.

Schedule a Service Request